|
NFPA/HMIS:
Health
1 Flammability 0
Reactivity 0
MATERIAL SAFETY
DATA SHEET U.S. DEPARTMENT OF LABOR
COMPLIES WITH USDL
SAFETY AND HEALTH REGULATIONS 29CFR1910.1200
________________________________________________________________________
SECTION 1
COMPANY AND PRODUCT IDENTIFICATION
PRODUCT NAME:
Shaw R2X Green Soil & Stain Remover RTU
PRODUCT USE:
Carpet Cleaner RTU
REVISION DATE:
11/01/08 (0)
________________________________________________________________________
SECTION 2
COMPOSITION/INFORMATION ON COMPONENTS
COMPONENTS
CAS NUMBER %
There are no components
contained in this material that are considered hazardous under
29CFR1910.1200.
_______________________________________________________________________
SECTION 3
HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Physical Properties: clear
to slightly hazy, pale yellow liquid/pH = 7.5-8.5
IMMEDIATE HEALTH EFFECTS
Eyes:
Overexposure may cause irritation to eyes.
Skin: Prolonged
and repeated contact may cause irritation to skin.
Inhalation:
Inhalation may cause irritation of upper respiratory passages.
Ingestion: Single
dose oral toxicity is low. Swallowing large amounts may be
harmful.
PRIMARY ROUTES OF ENTRY:
Eyes, skin contact/absorption, inhalation or ingestion.
SIGNS/SYMPTOMS OF
OVEREXPOSURE:
Gastrointestinal irritation (nausea, vomiting, diarrhea),
and/or irritation to the skin, eyes, nose, throat, and
respiratory tract.
TARGET ORGAN EFFECTS:
Irritation of the skin and eyes. Irritation of lungs possible
if mists/aerosols are inhaled.
REPRODUCTIVE/DEVELOPMENTAL
INFORMATION: No
data available.
CARCINOGENIC INFORMATION:
None of the ingredients of this material are listed as
carcinogens by IARC, NTP, or OSHA.
LONG TERM EFFECTS:
No data available.
________________________________________________________________
SECTION 4 FIRST AID
MEASURES
EYES:
Flush eyes with water for at least 15 minutes. If irritation
persists, consult a physician.
SKIN:
If irritation occurs, flush
skin with water for at least 15 minutes. If irritation
persists, consult a physician
INHALATION:
If symptoms of overexposure
develop, remove to fresh air. If symptoms persist, consult a
physician.
INGESTION:
Give 8 to 16 ounces of water
to dilute substance. Consult a physician or local Poison
Control Center. Never give anything by mouth to an unconscious
person.
SECTION 5
FIRE FIGHTING MEASURES
FLASHPOINT (° Fahrenheit):
No flash below
boil.
EXPLOSIVE LIMITS:
No data available.
AUTOIGNITION TEMPERATURE:
No data available.
HAZARDOUS PRODUCTS OF
COMBUSTION: In the
event of fire, the following may be released: Oxides of
carbon, nitrogen and sulfur.
EXTINGUISHING MEDIA:
Water spray, foam, dry
chemical powder of carbon dioxide.
FIRE FIGHTING INSTRUCTIONS:
Firefighters should wear proper protective equipment and
self-contained breathing apparatus with full face piece
operated in positive pressure mode. Move containers
from fire area if it can be done without risk. Use water to
keep fire-exposed containers cool.
NFPA/HMIS
RATINGS: Health: 1, Flammability: 0, Reactivity: 0
________________________________________________________________________
SECTION 6
ACCIDENTAL RELEASE MEASURES
SMALL SPILL:
For small spills, soak up material with an absorbent such as
clay, sand, or other suitable material and dispose of
properly. Flush area with water to remove trace residue.
LARGE SPILL:
Wear respirator and protective clothing as appropriate. Shut
off source of leak if it is safe to do so. Dike and contain
spilled material. Remove with vacuum trucks or pump to
storage/salvage containers. Soak up residue with an absorbent
such as clay, sand, or other suitable material. Flush area
with water to remove trace residue.
________________________________________________________________________
SECTION 7
HANDLING AND STORAGE
HANDLING:
Handle and open containers with care. Do not handle near an
open flame, heat, or other source of ignition.
STORAGE:
Store in a cool, well
ventilated place away from incompatible materials. Do not
store near an open flame, heat, or other source of ignition.
Protect material from direct sunlight.
________________________________________________________________________
SECTION 8
EXPOSURE CONTROLS / PERSONAL PROTECTION
EYE/FACE PROTECTION:
Chemical splash goggles in
compliance with OSHA regulations are advised; however, OSHA
regulations also permit other types of safety glasses. Consult
your safety representative.
SKIN PROTECTION:
Wear rubber gloves (consult your safety representative). Wear
impervious clothing and boots to prevent repeated or prolonged
skin contact.
RESPIRATORY PROTECTION:
If workplace
exposure limits of product or any component are exceeded, a
NIOSH/MSHA approved air supplied respirator is advised in
absence of proper environmental control. OSHA regulations also
permit other NIOSH/MSHA respirators (negative pressure type)
under specified conditions (consult your safety
representative). Engineering controls or
administrative controls should be implemented to reduce
exposure.
ENGINEERING CONTROLS:
Provide sufficient mechanical ventilation (general and local
exhaust) to maintain exposure below the level of overexposure
from known, suspected or apparent adverse effects.
________________________________________________________________________
SECTION 9
PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE:
Clear to slightly hazy, pale yellow liquid
pH:
7.5 – 8.5
VAPOR PRESSURE:
No data available.
VAPOR DENSITY:
No data available.
BOILING POINT:
212o F
SOLUBILITY IN WATER:
Soluble
EVAPORTATION RATE:
(water = 1) approximately 1
DENSITY:
1.02 g/mL +/- 0.02
______________________________________________________________________
SECTION 10
STABILITY AND REACTIVITY
CHEMICAL STABILITY:
Stable.
CONDITIONS TO AVOID:
None with proper storing and handling.
MATERIALS TO AVOID:
Oxidizing materials.
HAZARDOUS DECOMPOSITION:
Upon combustion, the following may be produced: Oxides of
carbon, nitrogen and sulfur.
HAZARDOUS POLYMERIZATION:
Will not occur.
______________________________________________________________________
SECTION 11
TOXICOLOGICAL INFORMATION
ROUTES OF EXPOSURE:
Skin absorption, eye contact, inhalation, and ingestion.
CARCINOGENITY:
None of the components of this
material are listed as carcinogens by IARC, NTP, or OSHA.
TERATOGENICITY, MUTAGENICITY,
OR OTHER REPRODUCTIVE EFFECTS:
No data available.
CONDITIONS AGGRAVATED BY
EXPOSURE: No data
available.
SYNERGISTIC MATERIALS:
No data available.
_________________________________________________________________
SECTION 12
ECOLOGICAL INFORMATION
No data available.
_______________________________________________________________________
SECTION 13
DISPOSAL CONSIDERATIONS
WASTE DISPOSAL INFORMATION:
Dispose in accordance with all applicable federal, state, and
local regulations.
RCRA INFORMATION:
If this material becomes a waste, it would not be considered
hazardous under 40CFR261.
________________________________________________________________________
SECTION 14
TRANSPORT INFORMATION
DOT INFORMATION – 49CFR172.101
Proper shipping
name: Compounds, cleaning, liquid – NOS
DOT Hazardous Class:
Non hazardous
Hazardous Components:
None
REPORTABLE QUANTITY–
49CFR172.101: Not
applicable
________________________________________________________________________
SECTION 15
REGULATORY INFORMATION
US FEDERAL REGULATIONS
TSCA Status: The
intentional components of this product are listed.
CERCLA Reportable
Quantities – 40CFR355 APPENDIX A: None.
SARA
313 – 40CFR372.65:
None.
STATE AND LOCAL
REGULATIONS
CALIFORNIA PROPOSITION
65:
None
MASSACHUSETTS:
None
NEW JERSEY:
None
PENNSYLVANIA:
None
________________________________________________________________________
SECTION 16
OTHER INFORMATION
This information relates only
to the specific material designated herein and does not relate
to use in combination with any other material or in any
process. Such information is to the best of our knowledge and
belief, accurate and reliable as of the date compiled.
However, no representation, warranty or guarantee is made as
to its accuracy, reliability, or completeness. It is the
user’s responsibility to satisfy himself as to the suitability
and completeness of this information for his own particular
use. We do not accept liability for any loss or damage that
may occur from the use of this information nor do we offer
warranty against patent infringement.
|
